The increasing need to reduce reliance on fossil-derived aviation fuels and mitigate environmental impacts has intensified research into renewable alternatives for aviation energy systems. The growing interest in ethanol-based fuels is primarily driven by their simple oxygen-rich molecular structure and advantageous physicochemical characteristics, yet experimental studies examining their application in hybrid power architectures, including micro-turboprop engine-based power sources, are still limited. This study presents an experimental investigation of ethanol–Jet A1 fuel blends used in a micro-turboprop engine operating as a power generation unit for unmanned aerial vehicle applications. Ethanol was blended with Jet A1 at volumetric fractions of 10%, 20% and 30% and the engine was tested under multiple operating regimes corresponding to different electrical power outputs. Exhaust gas temperature, electrical power output and gaseous emissions (CO and NOx) were measured for each operating condition. The results indicate that low ethanol fractions (E10) provide performance comparable to neat kerosene, while higher ethanol fractions lead to a reduction in exhaust gas temperature at low-power regimes due to the lower heating value and high latent heat of vaporization of ethanol. Emission measurements showed a decrease in NOx emissions with increasing ethanol content, associated with lower combustion temperatures, while CO emissions increased at low-power regimes due to incomplete combustion under lean conditions. Additionally, combustion instability was observed during rapid transitions from maximum to idle regime operation for higher ethanol blends, attributed to transient ultra-lean mixtures, evaporative cooling, and reduced reaction rates. The results demonstrate that ethanol–kerosene blends can be used in micro-turboprop systems at low blend ratios without major performance penalties, but transient operating conditions impose stability limits that must be considered in practical UAV power system applications.
Căldărar et al. (Thu,) studied this question.