Key points are not available for this paper at this time.
Abstract Background Aeration plays a critical role in the bioconversion of pretreated lignocellulose by enhancing lytic-polysaccharide-monooxygenase(LPMO)-supported enzymatic saccharification. However, its broader impact, particularly on fermentation inhibitors, remains insufficiently understood. The hypothesis that aeration not only promotes LPMO activity, which has been shown clearly in previous studies, but also affects fermentation inhibitors was investigated in experiments with softwood pretreatment liquids. The effects of aeration were explored through chemical analysis of fermentation inhibitors and through subsequent fermentations with the xylose-utilizing Saccharomyces cerevisiae yeast CelluX™4 to test the fermentability. Controls in which N 2 rather than air was supplied to the pretreatment liquids were used to distinguish between evaporation effects and effects caused by oxidation due to O 2 in air. In separate experiments, two redox-dependent detoxification methods, treatments with sulfite and laccase, were further investigated. Results While aeration had no negative effects on the subsequent fermentation of a sugar control, it compromised the fermentability of the pretreatment liquids. Compared to the N 2 control, subsequent fermentation of aerated samples showed reduced consumption of fermentable sugar (glucose, mannose, xylose) at 0.61 compared to 0.76 g L −1 h −1 , and lower ethanol productivity (0.23 vs. 0.30 g L −1 h −1 ). Apart from more commonly studied pretreatment by-products (such as aliphatic carboxylic acids, furan aldehydes, and phenolics), methanol (~ 1 g L −1 ) was detected in both pretreatment liquids. The methanol concentration decreased during gas addition, which was attributed to evaporation. Compared to the initial pretreatment liquid, aerated reaction mixtures exhibited slightly elevated levels of formaldehyde, but lower levels of furfural and vanillin. Sulfite detoxification was successful under both aeration and N 2 conditions. Treatment with laccase was found to have variable effects on the fermentability depending on the conditions applied. Conclusions The results underscore the dual role of aeration in softwood bioconversion, positive for promoting LPMO activity but potentially negative with respect to subsequent fermentability, and highlight the need to carefully tailor aeration strategies for the design of efficient biochemical processing of lignocellulosic feedstocks. Treatment with reducing agents, such as sulfite, emerges as a possibility to alleviate negative side-effects on the fermentability when aeration is used to promote LPMO activity.
Tang et al. (Wed,) studied this question.